Exhaust gas warning light on!

Talk about general things related to the new VW Scirocco in here.
User avatar
Zanic L3
Posts: 422
Joined: Sun Jun 25, 2017 6:56 pm
I drive a: GT 2.0 TSI
In: Deep Black
With a: DSG box
Options: Stage 2, Catless DP, Milltek catback.

Exhaust gas warning light on!

Post by Zanic L3 »

Image

Hey guys,

The exhaust gas warning light went on today after 5mins (+-2km's) driving. The light is always on and doesn't blink. Drove the car immediately back very slowly after that, haven't done any highways today/or floored it as the car was still warming up. Should I drive it later today again and see if the light is/goes out? The car doesn't feel like it's damage or something, I wouldn't notice it apart from the light. I hope it's not a serious problem like a cylinder misfire that I came across at the 1.4TSI's

Going to get it scanned Monday as it is Saturday today and there are no garages open.
The car in question is a 2009 2.0 TSI DSG (200hp model).


Anyone had this problem before? Is it a broken lambdasonde (Oxygen sensor)? Is this a serious problem that needs to be dealt with ASAP (obv I'm going to do it, but I'm just wondering if this is a crucial fail..) :(
User avatar
Zanic L3
Posts: 422
Joined: Sun Jun 25, 2017 6:56 pm
I drive a: GT 2.0 TSI
In: Deep Black
With a: DSG box
Options: Stage 2, Catless DP, Milltek catback.

Re: Exhaust gas warning light on!

Post by Zanic L3 »

Ok, did slowly drive around the block and the light kept on.

The car does behave normally imo. No sudden rev jumps/drops (misfires?) when idle, nothing noticeable in terms of sound, unusually smoke from the exhaust, no strange mechanical sounds,.. In terms of performance I don't know as I didn't floor it as the car was still cold.

Will bring it into VW on Monday. Hopefully, it's just something small, kinda need the car Tuesday.
User avatar
Daz GT TSI
Posts: 122
Joined: Tue Jul 04, 2017 7:56 pm
I drive a: GT 2.0 TSI
In: Deep Black
With a: DSG box
Options: Panoramic Sunroof, Heated Leather, Nav, Parking Sensors, H&R Lowering Springs, Revo Intake, Resonator Delete
Location: Cambridgeshire

Re: Exhaust gas warning light on!

Post by Daz GT TSI »

I had the same light come on just before Christmas, (Fault in the cat) or misfire, had it plugged in at the garage and says it was a faulty Post Cat Lambda Sensor (I'm still yet to get it put on) fault was cleared and the light hasn't popped up since.
But... I noticed it to be misfiring slightly, only on lower revs, and that was just a coil pack.
Hope you get it sorted mate
Let us know how you get on.


Sent from my iPhone using Tapatalk
Instagram: _daryll
User avatar
Zanic L3
Posts: 422
Joined: Sun Jun 25, 2017 6:56 pm
I drive a: GT 2.0 TSI
In: Deep Black
With a: DSG box
Options: Stage 2, Catless DP, Milltek catback.

Re: Exhaust gas warning light on!

Post by Zanic L3 »

Daz GT TSI wrote:I had the same light come on just before Christmas, (Fault in the cat) or misfire, had it plugged in at the garage and says it was a faulty Post Cat Lambda Sensor (I'm still yet to get it put on) fault was cleared and the light hasn't popped up since.
But... I noticed it to be misfiring slightly, only on lower revs, and that was just a coil pack.
Hope you get it sorted mate
Let us know how you get on.


Sent from my iPhone using Tapatalk
Thanks a lot for the reply,

So they just cleared the error/code? Without replacing or fixing anything?

I will keep you guys updated.
User avatar
Daz GT TSI
Posts: 122
Joined: Tue Jul 04, 2017 7:56 pm
I drive a: GT 2.0 TSI
In: Deep Black
With a: DSG box
Options: Panoramic Sunroof, Heated Leather, Nav, Parking Sensors, H&R Lowering Springs, Revo Intake, Resonator Delete
Location: Cambridgeshire

Re: Exhaust gas warning light on!

Post by Daz GT TSI »

Yes mate, I have the sensor just waiting to fit it...


Sent from my iPhone using Tapatalk
Instagram: _daryll
LHM
Posts: 91
Joined: Fri Sep 22, 2017 8:41 am
I drive a: Scirocco R
In: Rising Blue
With a: DSG box

Re: Exhaust gas warning light on!

Post by LHM »

at the moment it's pointless speculating what the fault could be without first plugging in and checking the fault code. These cars are littered with so many sensors, it could be anything! Plug in and take it from there.
User avatar
Zanic L3
Posts: 422
Joined: Sun Jun 25, 2017 6:56 pm
I drive a: GT 2.0 TSI
In: Deep Black
With a: DSG box
Options: Stage 2, Catless DP, Milltek catback.

Re: Exhaust gas warning light on!

Post by Zanic L3 »

*UPDATE*

Ok so I came back from VW and the inlet manifold needs replacing as I was already thinking after searching the forum. Do a search on keyword inlet manifold you will find a lot of threads about early 2.0TSI's with same issue.

€773 including labor. Car will only go into labor the 15th march so 3 weeks no joyrides :eyepop:


*VW also suggested me to only tank 98 and not 95 with a 2l
Last edited by Zanic L3 on Mon Feb 26, 2018 4:56 pm, edited 1 time in total.
User avatar
Zanic L3
Posts: 422
Joined: Sun Jun 25, 2017 6:56 pm
I drive a: GT 2.0 TSI
In: Deep Black
With a: DSG box
Options: Stage 2, Catless DP, Milltek catback.

Re: Exhaust gas warning light on!

Post by Zanic L3 »

Also they told me that I can still drive the car for small trips. Reckon I should just wait 3 weeks or sometimes drive it for small trips..?

Gonna be hard to not touch it for three weeks :fall: ahah
LHM
Posts: 91
Joined: Fri Sep 22, 2017 8:41 am
I drive a: Scirocco R
In: Rising Blue
With a: DSG box

Re: Exhaust gas warning light on!

Post by LHM »

i assume your car is out of warrenty?? If I was you I would be getting quotes from a VAG specialist because dealers charge WAY too much. As for fuel, yeah you should be using 98RON upwards on the 2.0T Petrol.
User avatar
Zanic L3
Posts: 422
Joined: Sun Jun 25, 2017 6:56 pm
I drive a: GT 2.0 TSI
In: Deep Black
With a: DSG box
Options: Stage 2, Catless DP, Milltek catback.

Re: Exhaust gas warning light on!

Post by Zanic L3 »

LHM wrote:i assume your car is out of warrenty?? If I was you I would be getting quotes from a VAG specialist because dealers charge WAY too much. As for fuel, yeah you should be using 98RON upwards on the 2.0T Petrol.
Yeah mate, the car is from 2009 it's out of warranty. I used 98 when I first got the car but quickly downgraded to 95, do you always tank 98?
LHM
Posts: 91
Joined: Fri Sep 22, 2017 8:41 am
I drive a: Scirocco R
In: Rising Blue
With a: DSG box

Re: Exhaust gas warning light on!

Post by LHM »

Zanic L3 wrote:
LHM wrote:i assume your car is out of warrenty?? If I was you I would be getting quotes from a VAG specialist because dealers charge WAY too much. As for fuel, yeah you should be using 98RON upwards on the 2.0T Petrol.
Yeah mate, the car is from 2009 it's out of warranty. I used 98 when I first got the car but quickly downgraded to 95, do you always tank 98?
mate, i ALLWAYS tank with 99!! I would NEVER EVER put 95 in my car. Dont get me wrong, it wont do it any harm, but your car will run better on 98 upwards. These 2.0TSI engines were designed to run on higher octane fuels. If you live in UK, Tesco do a 99ron fuel and its very cheap (well in my local area it is).
Delberthot
Posts: 50
Joined: Wed Aug 23, 2017 7:04 am
I drive a: Scirocco R
In: Candy White
With a: Manual box
Options: Cruise Control, Folding Mirrors

Re: Exhaust gas warning light on!

Post by Delberthot »

LHM wrote:
Zanic L3 wrote:
LHM wrote:i assume your car is out of warrenty?? If I was you I would be getting quotes from a VAG specialist because dealers charge WAY too much. As for fuel, yeah you should be using 98RON upwards on the 2.0T Petrol.
Yeah mate, the car is from 2009 it's out of warranty. I used 98 when I first got the car but quickly downgraded to 95, do you always tank 98?
mate, i ALLWAYS tank with 99!! I would NEVER EVER put 95 in my car. Dont get me wrong, it wont do it any harm, but your car will run better on 98 upwards. These 2.0TSI engines were designed to run on higher octane fuels. If you live in UK, Tesco do a 99ron fuel and its very cheap (well in my local area it is).
I filled my tank using Tesco Momentum at the weekend for the same cost as standard Shell petrol at a garage a couple of hundred yards away from it.

122.9p for Momentum v. 139.9p for VPower which was a difference of £7.30 filling the tank.
LHM
Posts: 91
Joined: Fri Sep 22, 2017 8:41 am
I drive a: Scirocco R
In: Rising Blue
With a: DSG box

Re: Exhaust gas warning light on!

Post by LHM »

[/quote]I filled my tank using Tesco Momentum at the weekend for the same cost as standard Shell petrol at a garage a couple of hundred yards away from it.

122.9p for Momentum v. 139.9p for VPower which was a difference of £7.30 filling the tank.[/quote]

wow those fuel prices are HIGH! Where in the UK are you? Tesco Momentum at my local was 117.9p on Saturday and my local VPower is 133.9p.
User avatar
Zanic L3
Posts: 422
Joined: Sun Jun 25, 2017 6:56 pm
I drive a: GT 2.0 TSI
In: Deep Black
With a: DSG box
Options: Stage 2, Catless DP, Milltek catback.

Re: Exhaust gas warning light on!

Post by Zanic L3 »

Here in Belgium it's +-
98 -> 1.44 / liter
95 -> 1.32 / l

or atleast that's what it was a few weeks ago, fcking expensive :cry: diesel is also the same priced as 95 atm
User avatar
Zanic L3
Posts: 422
Joined: Sun Jun 25, 2017 6:56 pm
I drive a: GT 2.0 TSI
In: Deep Black
With a: DSG box
Options: Stage 2, Catless DP, Milltek catback.

Re: Exhaust gas warning light on!

Post by Zanic L3 »

So I went for a small drive today and filled it up with 98.

Sorry for the angled video
[youtube][/youtube]

I really dont notice anything apart from the light, temps are ok, fuel consumption is ok (although it might be a little bit higher, i don't really check it all that often). It's not idling rough, misfiring or anything and drives as normal (max rev'd it to 3k)

The only thing I noticed is that it idles just below the stripe not sure if it was on it before.
Image

Maybe it's just leaking air out of the inlet very little and that's why the light comes on so early (as it also is an easy way to get the customers to buy new parts.. when they are still +-ok ?)
Non the less going to get the inlet manifold replaced the 15th.
LHM
Posts: 91
Joined: Fri Sep 22, 2017 8:41 am
I drive a: Scirocco R
In: Rising Blue
With a: DSG box

Re: Exhaust gas warning light on!

Post by LHM »

RPM idle looks spot on to me
User avatar
Zanic L3
Posts: 422
Joined: Sun Jun 25, 2017 6:56 pm
I drive a: GT 2.0 TSI
In: Deep Black
With a: DSG box
Options: Stage 2, Catless DP, Milltek catback.

Re: Exhaust gas warning light on!

Post by Zanic L3 »

Should I try to clear the error code and see if it comes on again?
How do I do this without vdcs? Unplug the battery for 15-30mins?

Just to see if the light comes back on
I believe it's still sitting in the memory even after clearing the error
User avatar
Zanic L3
Posts: 422
Joined: Sun Jun 25, 2017 6:56 pm
I drive a: GT 2.0 TSI
In: Deep Black
With a: DSG box
Options: Stage 2, Catless DP, Milltek catback.

Re: Exhaust gas warning light on!

Post by Zanic L3 »

[youtube][/youtube]


[youtube][/youtube]
LHM
Posts: 91
Joined: Fri Sep 22, 2017 8:41 am
I drive a: Scirocco R
In: Rising Blue
With a: DSG box

Re: Exhaust gas warning light on!

Post by LHM »

not sure how to clear the fault without VCDS sorry, but, why not purchase a used inlet manifold? There are LOADS on ebay and they are cheap. Worth a try? My first port of call would be to clear the fault code and see how the car drives and see if the Engine warning light and the fault returns.
User avatar
Zanic L3
Posts: 422
Joined: Sun Jun 25, 2017 6:56 pm
I drive a: GT 2.0 TSI
In: Deep Black
With a: DSG box
Options: Stage 2, Catless DP, Milltek catback.

Re: Exhaust gas warning light on!

Post by Zanic L3 »

LHM wrote:not sure how to clear the fault without VCDS sorry, but, why not purchase a used inlet manifold? There are LOADS on ebay and they are cheap. Worth a try? My first port of call would be to clear the fault code and see how the car drives and see if the Engine warning light and the fault returns.
I have ordered an OBD2 adapter (https://caristaapp.com/" onclick="window.open(this.href);return false;). Hopefully then I'll be able to read out the code and clean it
Post Reply